BMW R1100 S - Service Manual - Manuale di Officina - Reparaturanleitung
BMW R 1100 S
SERVICE MANUAL - MANUALE DI OFFICINA - REPARATURANLEITUNG
BMW R1100 S - SERVICE MANUAL - MANUALE DI OFFICINA - REPARATURANLEITUNG - Multilanguage (English, Deutsch, Italiano) Service Manual, to motorcycles BMW models R1100 S. CONTENTS: BMW R1100 S - REPAIR MANUAL - Repair Manual - Introduction - Contents - Maintenance schedule - Pre-delivery check - 00 Maintenance and general instructions --- Tightening torques --- Table of consumables --- Pre-delivery check --- General view of crated motorcycle --- Checking the crate for damage --- In case of damage in Germany --- In case of damage in importer markets --- Unpacking the motorcycle --- Installing remaining items on motorcycle --- Inspecting motorcycle for damage --- Checking that delivery is complete --- Filling and charging the battery --- Disengaging and raising the fuel tank --- Filling and charging the battery --- Checking engine oil level when cold, adding oil if... --- Checking clutch fluid level --- Checking brake fluid level --- Rear brake --- Front brake --- Checking headlight beam angle, adjusting if necess... --- Checking tightness of rear wheel studs --- Checking tyre pressures --- Final inspection and function check --- Final cleaning --- Handing over the motorcycle --- Maintenance --- Key to maintenance intervals --- Reading out MoDiTeC fault memory --- (Inspections I, II, III and IV) --- Changing engine oil, replacing oil filter element --- (Inspections I, II, III and IV) --- Changing oil in gearbox --- (Inspections III and IV) --- or every 2 years at the latest --- Changing oil in rear wheel drive; cleaning inducti... --- (Inspections I, III and IV) --- Every 40 000 km (24 000 miles) or every 2 years at... --- Replacing fuel filter --- (Inspection III) --- In normal operating conditions every 40 000 km (24... --- Checking battery fluid level and topping up if nec... --- (Inspections III and IV) --- Replacing intake air filter element --- (Inspection III) --- In very dirty and dusty operating conditions, repl... --- Replacing Poly-V belt --- (every 60 000 km/36 000 miles) --- (Inspection III) --- Poly-V belt adjusting procedure: --- Checking brake fluid level --- Front brake --- Rear brake --- Checking brake pads and discs for wear/replacing --- (Inspections II and III) --- Checking front brake pad wear --- Checking rear brake pad wear --- Checking brake disc wear --- Replacing brake pads, front brake --- Replacing brake pads, rear brake --- Changing brake fluid and bleeding brake system --- Change the brake fluid annually --- (Inspection IV) --- Bleeding front brake circuit/changing brake fluid --- Additional information for [ABS] --- Bleeding rear brake circuit/changing brake fluid --- Checking clutch fluid level --- (Inspections I, II and III) --- Changing the clutch fluid --- (Inspections III and IV) --- Every 40 000 km (24 000 miles) or every 2 years at... --- Checking tightness of rear wheel studs --- (Inspection I) --- Checking rear wheel bearing play by tilting wheel --- (Inspection III) --- Checking swinging arm bearings, adjusting if neces... --- (Inspections I and III) --- Greasing the side stand pivot --- (Inspections I, II and III) --- Checking function of side stand switch --- (Inspections I, II, III and IV) --- Checking/replacing spark plugs --- (Inspection II) check/(Inspection III) replace --- Tightening cylinder heads --- (Inspection I) --- Checking/adjusting valve clearances --- (Inspections I, II and III) --- Checking throttle cable for ease of movement, abra... --- (Inspections I, II, III and IV) --- Final inspection with road safety and functional c... --- (Inspections I, II, III and IV) --- Road safety check --- Roadworthiness check - 11 Engine --- Cutaway drawing of engine Lubricating-oil circuit --- Cooling-oil circuit --- Removing engine --- Disassembling engine --- Removing cylinder head cover --- Locking the engine at TDC --- Firing TDC --- Removing and installing chain tensioner --- Work instructions, timing-chain tensioner --- Removing valve gear holder --- Disassembling/assembling valve gear holder --- Removing cylinder head --- Disassembling, checking, repairing and reassemblin... --- Removing and installing valves --- Removing valve stem seals --- Checking valves for wear --- Remachining valve seat --- Checking and repairing cylinder head --- Checking valve guide for wear --- Replacing valve guides --- Installing valve and valve stem seal --- Removing cylinder --- Removing and disassembling piston --- Checking pistons and cylinders --- Assembling pistons --- Removing and installing conrod --- Removing and installing alternator mount cover wit... --- Removing alternator mount cover --- Replacing radial shaft seal in alternator mount co... --- Removing auxiliary shaft drive --- Removing oil pump --- Removing radial shaft seal from crankshaft with en... --- Disassembling crankcase --- Removing crankshaft, auxiliary shaft and timing ch... --- Removing and installing oil intake strainers --- Replacing oil level sight glass --- Removing and installing oil thermostat --- Removing conrods --- Checking conrods --- Measuring crankshaft bearing play --- Measuring radial bearing play --- Installing main bearings --- Measuring axial bearing play --- Measuring big end bearing play --- Assembling engine --- Installing conrods --- Installing crankshaft --- Installing timing chain tensioning and slide rails... --- Installing auxiliary shaft/timing chains --- Assembling engine block --- Installing radial shaft seals on crankshaft --- Installing the crankshaft-end radial shaft seal --- Installing the clutch-end radial shaft seal --- Installing clutch housing --- Installing oil pump --- Installing auxiliary shaft drive --- Installing piston --- Installing cylinder --- Installing cylinder head --- Adjusting valve clearances --- Installing right cylinder head --- Adjustment specification --- Installing left cylinder head --- Adjustment specification --- Installing alternator mount cover --- Installing magnetic gate/belt pulley --- Timing the ignition --- Installing alternator --- Installing engine - 12 Engine electrics --- Removing and installing coil and ignition leads --- Checking ignition coil resistance --- Removing and installing alternator --- Poly-V belt adjusting procedure: --- Disassembling/assembling alternator --- Checking alternator --- Checking armature for short to ground (earth) --- Disassembling/assembling alternator --- (Option 50 A) --- Checking alternator --- Checking armature for short to ground (earth) --- Removing and installing starter motor --- Disassembling/assembling starter motor --- Replacing carbon brushes --- Checking starter motor --- Checking starter relay --- Removing and installing magnetic gate --- Timing the ignition - 13 Fuel preparation and control --- Removing and installing air filter housing --- Removing and installing throttle- valve stub pipe --- Removing and installing throttle-valve potentiomet... --- Removing and installing Motronic control unit - 16 Fuel tank and lines --- Removing and installing fuel tank --- Removing and installing fuel filter, fuel pump and... --- Removing and installing fuel filter --- Removing and installing fuel pump and fuel level s... --- Checking fuel pump pressure --- Removing and installing fuel distributor and press... - 18 Exhaust system --- Removing and installing exhaust system --- Removing and installing silencer (muffler) --- Removing and installing exhaust manifolds - 21 Clutch --- Removing and installing clutch hydraulic line --- Removing and installing clutch slave cylinder --- Filling/bleeding clutch line --- Removing and installing clutch --- Removing clutch --- Installing clutch - 23 Gearbox --- Removing and installing gear-shift lever --- Removing gearbox --- Replacing the shaft sealing rings in the gearbox h... --- Replacing input shaft sealing ring at input end --- Replacing output shaft sealing ring --- Replacing input shaft sealing ring at output end --- Replacing shaft sealing ring for selector drum --- Replacing sealing ring for selector shaft --- Disassembling gearbox --- Removing gearbox housing --- Removing selector drum --- Disassembling/assembling selector shaft --- Removing gearbox shafts --- Replacing grooved ball bearing on intermediate sha... --- Disassembling/assembling input shaft --- Disassembling input shaft --- Assembling input shaft --- Disassembling/assembling output shaft --- Disassembling output shaft --- Assembling output shaft --- Checking endplay --- Checking/adjusting fully assembled length of gearb... --- Checking/adjusting fully assembled length of inter... --- Checking/adjusting fully assembled length of outpu... --- Checking/adjusting fully assembled length of input... --- Checking/adjusting fully assembled length of selec... --- Shimming selector shaft --- Assembling gearbox --- Installing input, output and intermediate shafts --- Installing selector shaft --- Installing selector drum --- Installing gearbox housing - 31 Front fork --- Removing and installing telescopic fork --- Removing and installing telescopic fork --- Removing and installing ball joint in slider tube ... --- Removing and installing ball joint in fork bridge --- Disassembling/assembling telescopic fork --- Disassembling telescopic fork --- Assembling telescopic fork --- Measuring telescopic fork --- Examining slider tube bridge and fork bridge --- Checking runout of fixed tube --- Checking runout of slider tube --- Removing and installing leading link --- Disassembling/assembling leading link --- Removing and installing front suspension strut - 32 Steering --- Removing and installing left handlebar fitting --- Removing and installing right handlebar fitting --- Removing and installing handlebar --- Removing and installing Bowden- cable divider, Bow... --- Disassembling Bowden-cable divider - 33 Rear wheel drive --- Removing, disassembling, reassembling and installi... --- Removing rear wheel drive --- Removing input bevel pinion --- Disassembling input bevel pinion --- Removing needle roller bearing for input bevel pin... --- Installing needle roller bearing for input bevel p... --- Assembling input bevel pinion --- Installing input bevel pinion --- Removing and disassembling crown wheel --- Assembling/installing crown wheel --- Checking/adjusting backlash --- Checking tooth contact pattern --- Shimming housing cover --- Installing housing cover --- Installing sliding element --- Removing and installing rear swinging arm --- Removing rear swinging arm --- Removing and installing taper roller bearing --- Removing and installing flexible gaiter --- Removing drive shaft --- Checking universal joint for wear --- Installing drive shaft --- Installing rear swinging arm --- Installing rear wheel drive --- Removing and installing suspension strut - 34 Brakes --- Removing and installing front brake caliper --- Disassembling and assembling front brake caliper --- Disassembling front brake caliper --- Assembling front brake caliper --- Removing and installing rear brake caliper --- Disassembling and assembling rear brake caliper --- Disassembling rear brake caliper --- Assembling rear brake caliper --- Removing and installing front brake disc --- Removing and installing rear brake disc --- Removing and installing front ABS sensor --- Adjusting front ABS sensor gap --- Marking sensor wheel --- Checking and adjusting sensor gap --- Removing and installing rear ABS sensor --- Adjusting rear ABS sensor gap --- Marking sensor wheel --- Checking and adjusting sensor gap --- Removing and installing rear brake master cylinder... --- Checking and adjusting play of piston rod --- Removing and installing footbrake lever --- Removing and installing ABS unit --- Removing the ABS unit --- Installing the ABS unit --- Removing and installing ABS relay and relay socket... --- Removing ABS relay --- Installing the ABS relay --- Removing ABS relay socket --- Installing the ABS relay base --- Removing and installing brake line --- Removing and installing front brake line --- Removing and installing rear brake line - 36 Wheels and tyres --- Removing and installing front wheel --- Removing front wheel --- Installing front wheel --- Removing and installing wheel bearings --- Removing and installing rear wheel --- Static balancing of front and rear wheels --- Checking front/rear wheel rim for runout - 46 Frame --- Exploded view of fairing sections --- Removing and installing fairing --- Removing and installing side panels --- Removing and installing tank trim --- Removing and installing fairing --- Removing and installing rear side panels --- Removing and installing tail section --- Removing and installing rear mudguard --- Removing and installing number-plate carrier --- Removing and installing front mudguard --- Removing and installing fairing bracket --- Removing and installing front frame --- Removing and installing main frame --- Removing and installing frame tail section --- Removing and installing side stand --- Checking running gear --- Measuring wheel track offset - 51 Equipment --- Removing and installing ignition switch/steering l... --- Removing and installing ignition/light switch --- Removing and installing lock barrel --- Drilling out lock barrel --- Removing and installing dualseat lock --- Removing and installing lock barrel for fuel tank ... --- Drilling out lock barrel - 52 Seat --- Removing and installing seat - 61 General electrical equipment --- Relay positions (central electrical equipment box)... --- Fuse assignments --- Left fuse box --- Right fuse box --- Frame wiring harness --- Wiring harness View from left --- Wiring harness View from right - 62 Instruments --- Removing and installing instrument panel --- Disassembling and assembling instrument panel - 63 Lights --- Removing and installing headlight --- Adjusting headlight BMW R1100 S - Reparaturanleitung - Reparaturanleitung - Vorwort - Gesamtinhaltsverzeichnis - Wartungsplan - ?bergabedurchsicht - 00 Wartung und allgemeine Hinweise --- Anziehdrehmomente --- Betriebsmitteltabelle --- ?bergabedurchsicht --- ?bersicht Verpackung --- Transportverschlag auf Sch?den pr?fen --- Im Schadensfall in Deutschland --- Im Schadensfall in Importeursm?rkten --- Motorrad auspacken --- Motorrad komplettieren --- Motorrad auf Sch?den pr?fen --- Vollst?ndigen Lieferumfang pr?fen --- Batterie bef?llen und laden --- Kraftstoffbeh?lter l?sen/anheben --- Batterie bef?llen und laden --- Motor?l in kaltem Zustand kontrollieren, ggf. erg?... --- Kupplungsfl?ssigkeitsstand pr?fen --- Bremsfl?ssigkeitsstand pr?fen --- Hinterradbremse --- Vorderradbremse --- Scheinwerfereinstellung kontrollieren , ggf. einst... --- Hinterradbefestigungsschrauben auf Festsitz pr?fen... --- Reifenluftdruck pr?fen --- Funktionspr?fung als Endkontrolle --- Abschlu?reinigung --- Fahrzeug?bergabe --- Wartung --- Verschl?sselung der Wartungsintervalle --- MoDiTeC-Fehlerspeicher auslesen --- (Inspektion I, II, III, IV) --- Motor?l wechseln, ?lfilter erneuern --- (Inspektion I, II, III, IV) --- ?l im Schaltgetriebe wechseln --- (Inspektion III, IV) --- oder sp?testens alle 2 Jahre --- ?l im Hinterradantrieb wechseln Induktivgeber am H... --- (Inspektion I, III, IV) --- alle 40 000 km oder sp?testens alle 2 Jahre --- Kraftstoffilter erneuern --- (Inspektion III) --- Im Regelfall alle 40 000 km, bei ung?nstigen Kraft... --- S?urestand der Batterie pr?fen/ erg?nzen, Batterie... --- (Inspektion III, IV) --- Ansaugluftfilter erneuern --- (Inspektion III) --- bei starkem Schmutz- und Staubanfall Ansaugluftfil... --- Poly-V-Riemen erneuern --- (alle 60 000 km) --- (Inspektion III) --- Einstellvorschrift Poly-V-Riemen: --- Bremsfl?ssigkeitsstand pr?fen --- Vorderradbremse --- Hinterradbremse --- Bremsbel?ge und -scheiben auf Verschlei? pr?fen/er... --- (Inspektion II, III) --- Bremsbel?ge vorn auf Verschlei? pr?fen --- Bremsbel?ge hinten auf Verschlei? pr?fen --- Bremsscheiben auf Verschlei? pr?fen --- Bremsbel?ge erneuern Vorderradbremse --- Bremsbel?ge erneuern Hinterradbremse --- Bremsfl?ssigkeit wechseln und Bremssystem entl?fte... --- Bremsfl?ssigkeit j?hrlich wechseln --- (Inspektion IV) --- Bremsfl?ssigkeit vorne entl?ften/ wechseln --- zus?tzlich bei [ABS] --- Bremsfl?ssigkeit hinten entl?ften/ wechseln --- Kupplungsfl?ssigkeitsstand pr?fen --- (Inspektion I, II, III) --- Kupplungsfl?ssigkeit wechseln --- (Inspektion III, IV) --- alle 40 000 km oder sp?testens alle 2 Jahre --- Hinterradbefestigungsschrauben auf Festsitz pr?fen... --- (Inspektion I) --- Hinterrad auf Kippspiel pr?fen --- (Inspektion III) --- Schwingenlager pr?fen ggf. einstellen --- (Inspektion I, III) --- Lagerung Seitenst?nder schmieren --- (Inspektion I, II, III) --- Seitenst?tzenschalter auf Funktion pr?fen --- (Inspektion I, II, III,IV) --- Z?ndkerzen pr?fen/erneuern --- (Inspektion II) pr?fen/(Inspektion III) erneuern --- Zylinderkopf nachziehen --- (Inspektion I) --- Ventilspiel kontrollieren/einstellen --- (Inspektion I, II, III) --- Gasseil auf Leichtg?ngigkeit, Scheuer- und Knickst... --- (Inspektion I, II, III, IV) --- Endkontrolle mit Pr?fung auf Verkehrs-/Funktionssi... --- (Inspektion I, II, III, IV) --- Zustandspr?fung --- Funktionspr?fung - 11 Motor --- Motor-Schnittdarstellung --- Schmier?lkreislauf --- K?hl?lkreislauf --- Motor ausbauen --- Motor zerlegen --- Zylinderkopfhaube ausbauen --- Motor in OT-Stellung arretieren --- Z?nd-OT --- Steuerkettenspanner aus-/einbauen --- Montagevorschrift Steuerkettenspanner --- Steuerungstr?ger ausbauen --- Steuerungstr?ger zerlegen/ zusammenbauen --- Zylinderkopf ausbauen --- Zylinderkopf zerlegen, pr?fen, instandsetzen, zusa... --- Ventile aus-/einbauen --- Ventilschaftabdichtungen ausbauen --- Ventile auf Verschlei? pr?fen --- Ventilsitz nacharbeiten --- Zylinderkopf pr?fen und instandsetzen --- Ventilf?hrung auf Verschlei? pr?fen --- Ventilf?hrungen ersetzen --- Ventil und Ventilschaftabdichtung einbauen --- Zylinder ausbauen --- Kolben ausbauen/zerlegen --- Kolben und Zylinder pr?fen --- Kolben zusammenbauen --- Pleuel aus-/einbauen --- Generatortr?gerdeckel bei eingebautem Motor aus-/e... --- Generatortr?gerdeckel ausbauen --- Radialwellendichtring Generatortr?gerdeckel erset... --- Nebenwellenantrieb ausbauen --- ?lpumpe ausbauen --- Radialwellendichtring Kurbelwelle bei eingebautem ... --- Kurbelgeh?use zerlegen --- Kurbelwelle, Nebenwelle, Steuerkettenspann- und Gl... --- ?lansaugk?rbe aus-/einbauen --- ?lstandsauge erneuern --- ?lthermostat aus-/einbauen --- Pleuel ausbauen --- Pleuel pr?fen --- Kurbelwellenlagerspiele messen --- Lagerspiel radial messen --- Kurbelwellenlager einbauen --- Lagerspiel axial messen --- Pleuellagerspiel messen --- Motor zusammenbauen --- Pleuel einbauen --- Kurbelwelle einbauen --- Steuerkettenspann- und Gleitschienen einbauen --- Nebenwelle/Steuerketten einbauen --- Motorgeh?use zusammenbauen --- Radialwellendichtringe Kurbelwelle einbauen --- Kurbelwellenseitigen Radialwellendichtring einbaue... --- Kupplungsgeh?useseitigen Radialwellendichtring ein... --- Kupplungsgeh?use einbauen --- ?lpumpe einbauen --- Nebenwellenantrieb einbauen --- Kolben einbauen --- Zylinder einbauen --- Zylinderkopf einbauen --- Ventilspiel einstellen --- Zylinderkopf rechts einbauen --- Einstellvorschrift --- Zylinderkopf links einbauen --- Einstellvorschrift --- Generatortr?gerdeckel einbauen --- Magnetschranke/Riemenscheibe einbauen --- Z?ndung einstellen --- Generator einbauen --- Motor einbauen - 12 Motor-Elektrik --- Z?ndspule und Z?ndkabel aus-/ einbauen --- Widerstandswert der Z?ndspule pr?fen --- Drehstromgenerator aus-/einbauen --- Einstellvorschrift Poly-V-Riemen: --- Drehstromgenerator zerlegen/ zusammenbauen --- Drehstromgenerator pr?fen --- Anker auf Masseschlu? pr?fen --- Drehstromgenerator zerlegen/ zusammenbauen --- Sonderausstattung 50 A --- Drehstromgenerator pr?fen --- Anker auf Masseschlu? pr?fen --- Anlasser aus-/einbauen --- Anlasser zerlegen/zusammenbauen --- Kohleb?rsten ersetzen --- Anlasser pr?fen --- Anla?relais pr?fen --- Magnetschranke aus-/einbauen --- Z?ndung einstellen - 13 Kraftstoffaufbereitung und -regelung --- Luftfiltergeh?use aus-/einbauen --- Drosselklappenstutzen aus-/ einbauen --- Drosselklappenpotentiometer aus-/ einbauen --- Motronic Steuerger?t aus-/ einbauen - 16 Kraftstoffbeh?lter und -leitungen --- Kraftstoffbeh?lter aus-/einbauen --- Kraftstoffilter, Kraftstoffpumpe, Kraftstoffstandg... --- Kraftstoffilter aus-/einbauen --- Kraftstoffpumpe, Kraftstoffstandgeber aus-/einbaue... --- Kraftstoffpumpendruck pr?fen --- Kraftstoffverteiler und Druckregler aus-/einbauen - 18 Auspuffanlage --- Auspuffanlage aus-/einbauen --- Schalld?mpfer aus-/einbauen --- Auspuffkr?mmer aus-/einbauen - 21 Kupplung --- Kupplungsleitung aus-/einbauen --- Kupplungsnehmerzylinder aus-/ einbauen --- Kupplungsleitung bef?llen/entl?ften --- Kupplung aus-/einbauen --- Kupplung ausbauen --- Kupplung einbauen - 23 Getriebe --- Schalthebel aus-/einbauen --- Getriebe ausbauen --- Wellendichtringe in Getriebegeh?use und Getriebede... --- Wellendichring f?r Antriebswelle antriebseitig ers... --- Wellendichtring f?r Abtriebswelle ersetzen --- Wellendichtring f?r Antriebswelle abtriebseitig er... --- Wellendichtring f?r Schaltwalze ersetzen --- Wellendichtring f?r Schaltwelle ersetzen --- Getriebe zerlegen --- Getriebegeh?use ausbauen --- Schaltwalze ausbauen --- Schaltwelle zerlegen/zusammenbauen --- Getriebewellen ausbauen --- Rillenkugellager der Zwischenwelle ersetzen --- Antriebswelle zerlegen/ zusammenbauen --- Antriebswelle zerlegen --- Antriebswelle zusammenbauen --- Abtriebswelle zerlegen/ zusammenbauen --- Abtriebswelle zerlegen --- Abtriebswelle zusammenbauen --- Axialspiel pr?fen --- Blockma?e der Getriebewellen und der Schaltwalze p... --- Blockma? der Zwischenwelle pr?fen/einstellen --- Blockma? der Abtriebswelle pr?fen/einstellen --- Blockma? der Antriebswelle pr?fen/einstellen --- Blockma? der Schaltwalze pr?fen/einstellen --- Schaltwelle ausdistanzieren --- Getriebe zusammenbauen --- Antriebs-, Abtriebs- und Zwischenwelle einbauen --- Schaltwelle einbauen --- Schaltwalze einbauen --- Getriebegeh?use einbauen - 31 Vorderradgabel --- Teleskopgabel aus-/einbauen --- Teleskopgabel aus-/einbauen --- Kugelgelenk in Gleitrohrbr?cke aus-/einbauen --- Kugelgelenk in Gabelbr?cke aus-/einbauen --- Teleskopgabel zerlegen/ zusammenbauen --- Teleskopgabel zerlegen --- Teleskopgabel zusammenbauen --- Teleskopgabel vermessen --- Gleitrohr-/Gabelbr?cke pr?fen --- Standrohr auf Schlag pr?fen --- Gleitrohr auf Schlag pr?fen --- L?ngslenker aus-/einbauen --- L?ngslenker zerlegen/ zusammenbauen --- Federbein vorne aus-/einbauen - 32 Lenkung --- Lenkerarmatur links aus-/einbauen --- Lenkerarmatur rechts aus-/ einbauen --- Lenker aus-/einbauen --- Seilzugverteiler, Bowdenzug f?r Gasbet?tigung und ... --- Seilzugverteiler zerlegen - 33 Hinterradantrieb --- Hinterradantrieb ausbauen, zerlegen, zusammenbauen... --- Hinterradantrieb ausbauen --- Antriebskegelrad ausbauen --- Antriebskegelrad zerlegen --- Nadellager f?r Antriebskegelrad ausbauen --- Nadellager f?r Antriebskegelrad einbauen --- Antriebskegelrad zusammenbauen --- Antriebskegelrad einbauen --- Tellerrad ausbauen, zerlegen --- Tellerrad zusammen-/einbauen --- Zahnflankenspiel pr?fen/einstellen --- Tragbild ?berpr?fen --- Geh?usedeckel ausdistanzieren --- Geh?usedeckel einbauen --- Schiebest?ck einbauen --- Hinterradschwinge aus-/einbauen --- Hinterradschwinge ausbauen --- Kegelrollenlager aus-/einbauen --- Faltenbalg aus-/einbauen --- Gelenkwelle ausbauen --- Kreuzgelenk auf Verschlei? pr?fen --- Gelenkwelle einbauen --- Hinterradschwinge einbauen --- Hinterradantrieb einbauen --- Federbein aus-/einbauen - 34 Bremsen --- Bremssattel vorne aus-/einbauen --- Bremssattel vorne zerlegen/ zusammenbauen --- Bremssattel vorne zerlegen --- Bremssattel vorne zusammenbauen --- Bremssattel hinten aus-/einbauen --- Bremssattel hinten zerlegen/ zusammenbauen --- Bremssattel hinten zerlegen --- Bremssattel hinten zusammenbauen --- Bremsscheibe vorne aus-/einbauen --- Bremsscheibe hinten aus-/einbauen --- ABS-Sensor vorne aus-/einbauen --- ABS-Sensorabstand vorne einstellen --- Sensorrad markieren --- Sensorabstand kontrollieren/einstellen --- ABS-Sensor hinten aus-/einbauen --- ABS-Sensorabstand hinten einstellen --- Sensorrad markieren --- Sensorabstand kontrollieren/einstellen --- Hauptbremszylinder hinten aus-/ einbauen --- Schn?ffelspiel der Kolbenstange kontrollieren/eins... --- Fu?bremshebel aus-/einbauen --- ABS-Einheit aus-/einbauen --- ABS-Einheit ausbauen --- ABS-Einheit einbauen --- ABS-Relais und Relais-Sockel aus-/ einbauen --- ABS-Relais ausbauen --- ABS-Relais einbauen --- ABS-Relais-Sockel ausbauen --- ABS-Relais-Sockel einbauen --- Bremsleitung aus-/einbauen --- Bremsleitung vorne aus-/einbauen --- Bremsleitung hinten aus-/einbauen - 36 R?der und Bereifung --- Vorderrad aus-/einbauen --- Vorderrad ausbauen --- Vorderrad einbauen --- Radlager aus-/einbauen --- Hinterrad aus-/einbauen --- Vorderrad/Hinterrad statisch auswuchten --- Vorderrad-/Hinterradfelge auf Schlag pr?fen - 46 Rahmen --- Kotfl?gel hinten aus-/einbauen --- Kennzeichentr?ger aus-/einbauen --- Kotfl?gel vorne aus-/einbauen --- Verkleidungshalter aus-/einbauen --- Rahmen vorne aus-/einbauen --- Hauptrahmen aus-/einbauen --- Rahmenheckteil aus-/einbauen --- Seitenst?tze aus-/einbauen --- Fahrwerkspr?fung --- Spurversatz messen --- ?bersicht Verkleidungsteile --- Verkleidung aus-/einbauen --- Seitenverkleidung aus-/einbauen --- Tankverkleidung aus-/einbauen --- Frontverkleidung aus-/einbauen --- Heckseitenverkleidung aus-/einbauen --- Heckverkleidung aus-/einbauen - 51 Ausstattung --- Z?ndlenkschlo? aus- und einbauen --- Z?ndlichtschalter aus-/einbauen --- Schlie?zylinder aus-/einbauen --- Schlie?zylinder ausbohren --- Sitzbankschlo? aus-/einbauen --- Schlie?zylinder f?r Kraftstoffbeh?lter aus-/einbau... --- Schlie?zylinder ausbohren - 52 Sitzbank --- Sitzbank aus-/einbauen - 61 Allgemeine Fahrzeugelektrik --- Relaisanordnung (Zentralelektrik) --- Sicherungsbelegung --- Linke Sicherungsbox --- Rechte Sicherungsbox --- Kabelbaumverlegung Fahrgestell --- Kabelbaumverlegung Ansicht links --- Kabelbaumverlegung Ansicht rechts - 62 Instrumente --- Kombiinstrument aus-/einbauen --- Kombiinstrument zerlegen/ zusammenbauen - 63 Leuchten --- Scheinwerfer aus-/einbauen --- Scheinwerfer einstellen BMW R1100 S - Istruzioni per le riparazioni - Istruzioni per le riparazioni - Prefazione - Elenco dei gruppi - Schema di manutenzione - Controllo gratuito preconsegna - 00 Manutenzione e informazioni generali --- Coppie di serraggio --- Tabella carburanti e lubrificanti --- Controllo gratuito preconsegna --- Schema dell?imballaggio --- Controllo danni alla gabbia di trasporto --- In caso di danno in Germania --- In caso di danno in un Paese d'importazione --- Disimballaggio della moto --- Completamento della moto --- Controllo dell'integrit? della moto --- Verifica della completezza della fornitura --- Riempimento e carica della batteria --- Distacco/sollevamento del serbatoio del carburante... --- Riempimento e carica della batteria --- Controllo olio motore a freddo, se necessario rabb... --- Controllo livello del liquido frizione --- Controllo livello del liquido freni --- Freno della ruota posteriore --- Freno della ruota anteriore --- Controllo regolazione dei proiettori, se necessari... --- Controllo viti di arresto della ruota posteriore i... --- Controllo pressione di gonfiaggio pneumatici --- Controllo funzionamento come collaudo finale --- Pulizia finale --- Consegna della motocicletta --- Manutenzione --- Codifica degli intervalli di manutenzione --- Consultazione della memoria difetti del MoDiTeC --- (Ispezioni I, II, III, IV) --- Sostituzione dell'olio motore, del filtro olio --- (Ispezioni I, II, III, IV) --- Sostituzione dell'olio nel cambio meccanico --- (Ispezioni III, IV) --- o comunque al massimo ogni 2 anni --- Sostituzione dell'olio della trasmissione posterio... --- (Ispezioni I, III, IV) --- ogni 40.000 km o comunque al massimo ogni 2 anni --- Sostituzione del filtro carburante --- (Ispezione III) --- In generale ogni 40.000 km, con carburanti di scar... --- Controllo/rabbocco livello dell'acido della batter... --- (Ispezioni III, IV) --- Sostituzione del filtro dell'aria --- (Ispezione III) --- in caso di notevoli depositi di impurit? e polvere... --- Sostituzione della cinghia Poly-V --- (ogni 60.000 km) --- (Ispezione III) --- Norma di regolazione cinghia Poly-V: --- Controllo del livello del liquido freni --- Freno della ruota anteriore --- Freno della ruota posteriore --- Controllo usura/sostituzione pastiglie e dischi fr... --- (Ispezioni II, III) --- Controllo usura pastiglie anteriori --- Controllo usura pastiglie posteriori --- Controllo usura dischi freni --- Sostituzione delle pastiglie dei freni della ruota... --- Sostituzione delle pastiglie dei freni della ruota... --- Cambio del liquido freni e sfiato dell'impianto fr... --- Sostituzione annuale del liquido dei freni --- (Ispezione IV) --- Sfiato/sostituzione del liquido freno anteriore --- Interventi supplementari con [ABS] --- Sfiato/sostituzione del liquido freno posteriore --- Controllo livello del liquido della frizione --- (Ispezioni I, II, III) --- Cambio del liquido della frizione --- (Ispezioni III, IV) ogni 40.000 km o comunque al m... --- Controllo viti di arresto della ruota posteriore i... --- (Ispezione I) --- Controllo gioco di ribaltamento ruota posteriore --- (Ispezione III) --- Controllo ed eventuale regolazione cuscinetto brac... --- (Ispezioni I, III) --- Lubrificazione del supporto del cavalletto lateral... --- (Ispezioni I, II, III) --- Controllo funzionamento dell'interruttore del cava... --- (Ispezioni I, II, III, IV) --- Controllo/sostituzione candele --- (Ispezione II) controllo/(Ispezione III) sostituzi... --- Serraggio della testata cilindri --- (Ispezione I) --- Controllo/regolazione gioco valvole --- (Ispezioni I, II, III) --- Controllare che il cavo dell'acceleratore non pres... --- (Ispezioni I, II, III, IV) --- Controllo finale con prova della sicurezza della m... --- (Ispezioni I, II, III, IV) --- Controllo condizioni generali --- Controllo funzionamento - 11 Motore --- Vista in sezione motore --- Circuito olio lubrificante --- Circuito olio refrigerante --- Smontaggio motore --- Scomposizione motore --- Smontaggio coperchio della testata cilindri --- Arresto del motore in posizione PMS --- PMS accensione: --- Smontaggio/rimontaggio tenditore della catena di d... --- Istruzioni per il montaggio del dispositivo tendit... --- Smontaggio supporto di comando --- Scomposizione/ricomposizione supporto di comando --- Smontaggio testata cilindri --- Scomposizione, controllo, riparazione, ricomposizi... --- Smontaggio/rimontaggio valvole --- Smontaggio guarnizioni steli valvole --- Controllo usura valvole --- Ripassatura della sede valvola --- Controllo e riparazione testata cilindri --- Controllare usura guida-valvola --- Sostituzione delle guide valvole --- Montaggio valvola e guarnizione stelo valvola --- Smontaggio cilindri --- Smontaggio/scomposizione pistoni --- Controllo pistoni e dei cilindri --- Ricomposizione pistoni --- Smontaggio/rimontaggio bielle --- Smontaggio/rimontaggio coperchio del supporto per ... --- Smontaggio coperchio supporto alternatore --- Sostituzione paraolio radiale del coperchio del su... --- Smontaggio comando albero secondario --- Smontaggio pompa olio --- Smontaggio paraolio radiale albero motore con moto... --- Scomposizione basamento --- Smontaggio albero motore, albero secondario, patti... --- Smontaggio/montaggio succhieruole olio --- Sostituzione vetro spia olio --- Smontaggio/montaggio termostato dell'olio --- Smontaggio bielle --- Controllo bielle --- Misurazione giochi dei cuscinetti albero motore --- Misurazione gioco radiale cuscinetti --- Montaggio cuscinetti albero motore --- Misurazione gioco assiale cuscinetti --- Misurazione gioco dei cuscinetti bielle --- Assemblaggio del motore --- Montaggio bielle --- Montaggio albero motore --- Montaggio pattino tenditore e pattino scorrevole c... --- Montaggio albero secondario/catene di distribuzion... --- Ricomposizione carter motore --- Montaggio paraolio radiali dell'albero motore --- Montaggio dei paraolio radiali sul lato albero mot... --- Montaggio del paraolio radiale sul lato albero mot... --- Montaggio scatola frizione --- Montaggio pompa olio --- Montaggio comando albero secondario --- Montaggio pistoni --- Montaggio cilindri --- Montaggio testata cilindri --- Regolazione gioco-valvole --- Montaggio testata cilindri destra --- Prescrizione di regolazione --- Montaggio della testata cilindri sinistra --- Prescrizione di regolazione --- Montaggio coperchio del supporto per l'alternatore... --- Montaggio rel? magnetico/della puleggia --- Registrazione dell'accensione --- Montaggio alternatore --- Montaggio motore - 12 Motore - impianto elettrico --- Smontaggio/rimontaggio bobina d'accensione e cavo ... --- Controllo valore di resistenza della bobina d'acce... --- Smontaggio/rimontaggio alternatore --- Norma di regolazione cinghia Poly-V: --- Scomposizione/ricomposizione alternatore --- Controllo alternatore --- Controllo contatto a massa dell'indotto --- Scomposizione/ricomposizione alternatore --- (Equipaggiamento speciale 50 A) --- Controllo alternatore --- Controllo contatto a massa dell'indotto --- Smontaggio/rimontaggio motorino di avviamento --- Scomposizione/ricomposizione motorino di avviament... --- Sostituzione delle spazzole --- Controllo motorino di avviamento --- Controllo rel? motorino di avviamento --- Smontaggio/rimontaggio rel? elettromagnetico --- Registrazione dell'accensione - 13 Carburazione --- Smontaggio/rimontaggio corpo del filtro aria --- Smontaggio/rimontaggio del bocchettone farfalla --- Smontaggio/rimontaggio del potenziometro della far... --- Smontaggio/rimontaggio centralina Motronic - 16 Serbatoio e tubazioni carburante --- Smontaggio/rimontaggio serbatoio del carburante --- Smontaggio/rimontaggio filtro carburante, pompa c... --- Smontaggio/rimontaggio filtro del carburante --- Smontaggio/rimontaggio pompa carburante, indicato... --- Controllo della pressione pompa carburante --- Smontaggio/rimontaggio ripartitore carburante e re... - 18 Impianto di scarico --- Smontaggio/rimontaggio impianto di scarico --- Smontaggio/rimontaggio marmitta --- Smontaggio/rimontaggio collettore di scarico - 21 Frizione --- Smontaggio/rimontaggio tubazione frizione --- Smontaggio/rimontaggio cilindro ricevitore frizion... --- Riempimento/sfiato tubazione frizione --- Smontaggio/rimontaggio frizione --- Smontaggio frizione --- Montaggio frizione - 23 Cambio --- Smontaggio/rimontaggio leva del cambio --- Smontaggio cambio --- Sostituzione anelli paraolio nella scatola del cam... --- Sostituzione anello paraolio per l'albero d'entrat... --- Sostituzione anello paraolio per l'albero d'uscita... --- Sostituzione anello paraolio per l'albero d'entrat... --- Sostituzione anello paraolio per il tamburo selett... --- Sostituzione anello paraolio per l'albero del camb... --- Scomposizione cambio --- Smontaggio scatola del cambio --- Smontaggio tamburo selettore --- Scomposizione/ricomposizione albero del cambio --- Smontaggio alberi del cambio --- Sostituzione cuscinetti a sfere a gole profonde de... --- Scomposizione/ricomposizione albero di entrata --- Scomposizione albero di entrata --- Ricomposizione albero di entrata --- Scomposizione/ricomposizione albero d'uscita --- Scomposizione albero d'uscita --- Ricomposizione albero d'uscita --- Controllo gioco assiale --- Controllo/regolazione quote alberi del cambio e de... --- Controllo/regolazione quote alberi intermedi --- Controllo/regolazione quote alberi di uscita --- Controllo/regolazione quote alberi di entrata --- Controllo/regolazione quote tamburo selettore --- Regolazione distanza albero del cambio --- Ricomposizione cambio --- Montaggio dell'albero di entrata, albero d'uscita ... --- Montaggio albero del cambio --- Montaggio tamburo selettore --- Montaggio scatola del cambio - 31 Forcella ruota anteriore --- Smontaggio/rimontaggio forcella telescopica --- Smontaggio/rimontaggio forcella telescopica --- Smontaggio/montaggio giunto a snodo nel ponte a tu... --- Smontaggio/montaggio giunto a snodo nell'elemento ... --- Scomposizione/ricomposizione forcella telescopica --- Scomposizione forcella telescopica --- Ricomposizione forcella telescopica --- Misurazione forcella telescopica --- Controllo ponte a tubi scorrevoli/elemento triango... --- Controllo squilibrio della canna del fodero --- Controllo squilibrio del fodero --- Smontaggio/rimontaggio braccio longitudinale --- Scomposizione/ricomposizione braccio longitudinale... --- Smontaggio/rimontaggio ammortizzatore telescopico ... - 32 Manubrio --- Smontaggio/rimontaggio comandi sul manubrio a sini... --- Smontaggio/rimontaggio comandi sul manubrio a dest... --- Smontaggio/rimontaggio manubrio --- Smontaggio/montaggio ripartitore cavi, cavo Bowden... --- Scomposizione del ripartitore cavi - 33 Trazione posteriore --- Smontaggio, scomposizione, ricomposizione e rimon... --- Smontaggio trazione posteriore --- Smontaggio pignone di comando --- Scomposizione pignone di comando --- Smontaggio cuscinetto a rullini del pignone di com... --- Montaggio del cuscinetto a rullini del pignone di ... --- Ricomposizione pignone di comando --- Montaggio pignone di comando --- Smontaggio/scomposizione corona dentata --- Composizione/rimontaggio corona dentata --- Controllo/registrazione gioco sui fianchi dei den... --- Controllo portanza --- Allineamento coperchio scatola --- Montaggio coperchio scatola --- Montaggio dell'estremo scanalato --- Smontaggio/rimontaggio braccio oscillante ruota po... --- Smontaggio braccio oscillante ruota posteriore --- Smontaggio/rimontaggio cuscinetti a rulli conici --- Smontaggio/rimontaggio soffietto --- Smontaggio albero di trasmissione --- Controllo usura del giunto cardanico --- Montaggio albero di trasmissione --- Montaggio forcellone ruota posteriore --- Montaggio trazione posteriore --- Smontaggio/rimontaggio ammortizzatore telescopico... - 34 Freni --- Smontaggio/rimontaggio pinza freno anteriore --- Scomposizione/ricomposizione pinza freno anteriore... --- Scomposizione pinza freno anteriore --- Ricomposizione pinza freno anteriore --- Smontaggio/rimontaggio pinza freno posteriore --- Scomposizione/ricomposizione pinza freno posterior... --- Scomposizione pinza freno posteriore --- Ricomposizione pinza freno posteriore --- Smontaggio/rimontaggio disco freno anteriore --- Smontaggio/rimontaggio disco freno posteriore --- Smontaggio/rimontaggio sensore ABS anteriore --- Regolazione distanza sensore ABS anteriore --- Identificazione ruota sensore --- Controllo/regolazione distanza sensori --- Smontaggio/rimontaggio sensore ABS posteriore --- Regolazione distanza sensore ABS posteriore --- Identificazione ruota sensore --- Controllo/regolazione distanza sensori --- Smontaggio/rimontaggio pompa freno posteriore --- Controllo/regolazione gioco di compensazione dello... --- Smontaggio/rimontaggio leva freno a pedale --- Smontaggio/rimontaggio unit? ABS --- Smontaggio unit? ABS --- Montaggio unit? ABS --- Smontaggio/rimontaggio rel? ABS e zoccolo rel? --- Smontaggio rel? ABS --- Montaggio rel? ABS --- Smontaggio zoccolo rel? ABS --- Montaggio zoccolo rel? ABS --- Smontaggio/rimontaggio tubazione dei freni --- Smontaggio/rimontaggio tubazione freno anteriore --- Smontaggio/rimontaggio tubazione freno posteriore - 36 Ruote e pneumatici --- Smontaggio/rimontaggio ruota anteriore --- Smontaggio ruota anteriore --- Montaggio ruota anteriore --- Smontaggio/rimontaggio cuscinetti ruota --- Smontaggio/rimontaggio ruota posteriore --- Equilibratura statica ruota anteriore/ posteriore... --- Controllo squilibrio cerchio ruota anteriore/poste... - 46 Telaio --- Vista generale parti del rivestimento --- Smontaggio/montaggio rivestimento --- Smontaggio/montaggio rivestimento laterale --- Smontaggio/montaggio rivestimento serbatoio --- Smontaggio/montaggio rivestimento frontale --- Smontaggio/montaggio rivestimento laterale posteri... --- Smontaggio/montaggio rivestimento posteriore --- Smontaggio/rimontaggio parafango posteriore --- Smontaggio/montaggio supporto targa --- Smontaggio/rimontaggio parafango anteriore --- Smontaggio/montaggio intelaiatura rivestimento --- Smontaggio/rimontaggio telaio anteriore --- Smontaggio/montaggio telaio principale --- Smontaggio/montaggio parte posteriore telaio --- Smontaggio/rimontaggio cavaletto laterale --- Controllo assetto --- Misurazione disassamento - 51 Dotazione --- Smontaggio/rimontaggio blocchetto d'accensione e b... --- Smontaggio/rimontaggio interruttore d'accensione e... --- Smontaggio/rimontaggio cilindretto chiusura --- Perforazione del cilindretto di chiusura --- Smontaggio/montaggio serratura sella --- Smontaggio/rimontaggio cilindretto chiusura per se... --- Perforazione cilindretto chiusura - 52 Sella --- Smontaggio/rimontaggio sella - 61 Impianto elettrico generale --- Disposizione rel? (impianto elettrico centrale) --- Posizione fusibili --- Scatola fusibili sinistra --- Scatola fusibili destra --- Posa fascio cavi telaio --- Posa cablaggio Vista a sinistra --- Posa cablaggio Vista a destra - 62 Strumenti --- Smontaggio/rimontaggio strumento combinato --- Scomposizione/ricomposizione strumento combinato - 63 Luci --- Smontaggio/rimontaggio del proiettore --- Orientamento del proiettore
BMW R1100 S - Service Manual - Manuale di Officina - Reparaturanleitung
inicio - index
coche - car
moto
4x4
quad - buggy
cami?n - truck
e-mail