Dodge Viper (ZB)
DODGE VIPER ZB - WORKSHOP, SERVICE, REPAIR MANUAL
DODGE VIPER ZB - WORKSHOP, SERVICE, REPAIR MANUAL - English Workshop Manual / Repair Manual, to vehicles Dodge Viper ZB. CONTENTS: WORKSHOP MANUAL - 2005 ZB SRT-10 Workshop Manual -- FOREWORD -- GROUP TAB LOCATOR -- in-INTRODUCTION -- Body Code Plate -- E-Mark Label -- Fastener Identification -- Fastener Usage -- International Symbols -- Manufacture Plate -- Metric System -- Torque References -- Veci Label -- Vehicle Identification Number -- Vehicle Certification Label -- 0-LUBRICATION & MAINTENANCE -- International Symbols -- Parts & Lubricant Recommendation -- Fluid Types -- Fluid Capacities -- Fluid Fill/Check Locations -- Lubrication Points -- Maintenance Schedules -- Hoisting -- Jump Starting -- Towing -- Vehicle Storage -- 2-SUSPENSION -- Suspension -- Front Suspension -- Rear Suspension -- 3-DIFFERENTIAL & DRIVELINE -- Propeller Shaft -- Half Shaft -- Rear Axle - 226ria -- 5-BRAKES -- Brakes - Base -- Brakes - Abs -- 6-CLUTCH -- Clutch -- Clutch Disc -- Clutch Release Bearing -- Flywheel -- Linkage -- Master Cylinder -- Clutch Pedal Position Switch -- 7-COOLING -- Cooling -- Accessory Drive -- 8a-AUDIO/VIDEO -- Audio -- Amplifier -- Antenna -- Antenna Module -- Instrument Panel Antenna Cable -- Radio -- Radio Noise Suppression Components -- Speaker -- 8b-CHIME/BUZZER -- Chime/Buzzer -- 8e-ELECTRONIC CONTROL MODULES -- Body Control Module -- Controller Antilock Brake -- Data Link Connector -- Powertrain Control Module -- 8f-ENGINE SYSTEMS -- Battery System -- Charging -- Starting -- 8g-HEATED SYSTEMS -- Heated Glass -- Rear Window Defogger Relay -- Rear Window Defogger Switch -- Rear Window Defogger Grid -- 8h-HORN -- Horn System -- Horn -- Horn Switch -- 8i-IGNITION CONTROL -- Ignition Control -- Camshaft Position Sensor -- Ignition Coil -- Spark Plug -- Spark Plug Cable -- Starter Button -- 8j-INSTRUMENT CLUSTER -- Instrument Cluster -- Airbag Indicator -- Instrument Cluster Gauge Pack -- Instrument Cluster Gauge Pack Lens -- Instrument Cluster Lens -- Pass Airbag Off Indicator -- Seat Belt Warning Indicator -- 8l-LAMPS -- Lamps/Lighting - Exterior -- Backup Lamp -- Back Up Lamp Unit -- Brake Lamp Switch -- Center High Mounted Stop Lamp Unit -- Fog Lamp - Front -- Fog Lamp Unit - Front -- Fog Lamp - Rear (Export) -- Fog Lamp Unit - Rear (Export) -- Headlamp -- Headlamp Unit -- License Plate Lamp -- License Plate Lamp Unit -- Multi-Function Switch -- Multi-Function Switch - Export -- Front Side Marker Lamp -- Rear Side Marker Lamp -- Repeater Lamp - Export -- Tail Lamp -- Tail Lamp Unit -- 8n-POWER SYSTEMS -- Power Locks -- Power Mirrors -- Power Windows -- 8o-RESTRAINTS -- Restraints -- Child Tether -- Clockspring -- Driver Airbag -- Occupant Restraint Controller -- Passenger Airbag -- Passenger Airbag On / Off Switch -- Seat Belt & Retractor -- Seat Belt Buckle -- Seat Belt Switch -- Seat Belt Tensioner -- 8q-VEHICLE THEFT SECURITY -- Vehicle Theft Security -- Hood Ajar Switch -- Vtss Disarm Switch -- Vtss Indicator -- 8r-WIPERS/WASHERS -- Wipers/Washers -- Washer Hoses / Tubes -- Washer Nozzle -- Washer Pump Motor -- Washer Reservoir -- Wiper Arms -- Wiper Blades -- Wiper Module -- Wiper Motor -- Wiper/Washer Switch -- Headlamp Washers - Export -- Headlamp Washer Hoses / Tubes - Export -- Headlamp Washer Nozzle - Export -- Headlamp Washer Pump Motor - Export -- Washer Pump Motor - Export -- Headlamp Washer Reservoir - Export -- 8w-WIRING -- 8w-01 Wiring Diagram Information -- 8w-02 Component Index -- 8w-10 Power Distribution -- 8w-15 Ground Distribution -- 8w-18 Bus Communications -- 8w-20 Charging System -- 8w-21 Starting System -- 8w-30 Fuel/Ignition System -- 8w-35 Antilock Brakes -- 8w-39 Vehicle Theft Security System -- 8w-40 Instrument Cluster -- 8w-41 Horn/Cigar Lighter/Power Outlet -- 8w-42 Air Conditioning/Heater -- 8w-43 Occupant Restraint System -- 8w-44 Interior Lighting -- 8w-45 Body Control Module -- 8w-47 Audio System -- 8w-48 Rear Window Defogger -- 8w-50 Front Lighting -- 8w-51 Rear Lighting -- 8w-52 Turn Signals -- 8w-53 Wipers -- 8w-56 Convenience Systems -- 8w-60 Power Windows -- 8w-61 Power Door Locks -- 8w-62 Power Mirrors -- 8w-70 Splice Information -- 8w-80 Connector Pin-Outs -- 8w-91 Connector/Ground/Splice Location -- 8w-97 Power Distribution -- 9-ENGINE -- Engine - 8.3l -- Air Cleaner Element -- Air Cleaner Housing -- Engine Mounts -- Intake Manifold -- Exhaust Manifold -- Cylinder Head(S) -- Cylinder Head Cover(S) -- Rocker Arms -- Valve Springs/Seals -- Intake/Exhaust - Valves/Seats/Guides -- Timing Chain Cover -- Timing Chain And Sprockets -- Lubrication -- Oil -- Oil Cooler & Lines -- Oil Pan -- Oil Pump -- Oil Pressure Sensor -- Sensor-Oil Temperature -- Engine Block -- Hydraulic Tappets -- Camshaft -- Piston & Connecting Rod -- Piston Rings -- Connecting Rod Bearings -- Crankshaft Damper -- Crankshaft Oil Seal - Front -- Crankshaft Oil Seal And Retainer - Rear -- Crankshaft Main Bearings -- Crankshaft -- Crankshaft Pilot Bearing -- 11-EXHAUST SYSTEM -- Exhaust System -- Pipe Clamps -- Heat Shields -- Catalytic Converter(S) -- Resonator(S) -- Spout Assembly - Left/Right -- H-Pipe -- Heat Shields - Export -- Resonator(S) - Export -- Spout Assembly - Export -- H-Pipe - Export -- Exhaust Pipe - Export -- Support Bracket And Isolator - Export -- Exhaust Solenoid - Export -- 13-FRAME & BUMPERS -- Frame & Bumpers -- Front Fascia -- Front Fascia - Export -- Front Bumper Reinforcement -- Front Bumper Reinforcement - Export -- Rear Fascia -- Rear Bumper Foam -- Rear Bumper -- Front Tow Eye Bracket - Export -- Bracket - Rear License Plate Export -- Frame -- Rear Transmission Crossmember -- 14-FUEL SYSTEM -- Fuel Delivery -- Fuel Injection -- 19-STEERING -- Steering -- Column -- Gear -- 21-TRANSMISSION/TRANSAXLE -- Manual Transmission - T56 -- 22-TIRES/WHEELS -- Tires/Wheels -- Tire Pressure Monitoring (Tpm) -- Module - Tpm -- Sensor - Tpm -- Tires -- Wheels -- Wheel Mounting Studs - Front -- Wheel Mounting Studs - Rear -- 23-BODY -- Body -- Convertible Top -- Decklid -- Door - Front -- Exterior -- Hood -- Instrument Panel -- Interior -- Paint -- Seats -- Stationary Glass -- Weatherstrip/Seals -- 24-HEATING & AIR CONDITIONING -- Heating & Air Conditioning -- Controls -- Distribution -- 25-EMISSIONS CONTROL -- Emissions Control -- Evaporative Emissions -- INDEX -- COMMENTS POWERTRAIN - ZB SRT-10 BUX Powertrain -- TABLE OF CONTENTS -- 1.0 INTRODUCTION -- 1.1 System Coverage -- 1.2 Six-Step Trouble Shooting Procedure -- 2.0 IDENTIFICATION OF SYSTEM -- 3.0 SYSTEM DESCRIPTION AND FUNCTIONAL OPERATION -- 3.1 General Description -- 3.2 Function Operation -- 3.3 Diagnostic Trouble Codes -- 3.4 Using The Drbiii -- 3.5 Drbiii Error Messages And Blank Screen -- 4.0 DISCLAIMERS, SAFETY, WARNINGS -- 4.1 Disclaimers -- 4.2 Safety -- 4.3 Warnings And Cautions -- 5.0 REQUIRED TOOLS AND EQUIPMENT -- 6.0 ACRONYMS -- 7.0 DIAGNOSTIC INFORMATION AND PROCEDURES -- Communication -- Driveability - Gas -- Starting -- Verification Tests -- 8.0 COMPONENT LOCATIONS -- 8.1 Control Modules And Pdc -- 8.2 Data Link Connector -- 8.3 Sensors And Solenoids -- 8.4 Fuel System -- 9.0 CONNECTOR PINOUTS -- A/C Compressor Clutch - Black 2 Way -- A/C Low Pressure Switch - Dk. Green 2 Way -- A/C Pressure Transducer - Black 4 Way -- Battery Temperature Sensor - 2 Way -- Brake Lamp Switch - Black 6 Way -- Camshaft Position Sensor - Gray 3 Way -- Clockspring - White 8 Way -- Clutch Interlock Switch - Dk.Green 2 Way -- Crankshaft Position Sensor - Black 3 Way -- Data Link Connector - Black 16 Way -- Engine Coolant Temperature Sensor - Black 2 Way -- Engine Oil Pressure Sensor - Black 3 Way -- Engine Oil Temperature Sensor - Black 2 Way -- Evap/Purge Solenoid - Black 2 Way -- Fuel Injector No. 1 - Black 2 Way -- Fuel Injector No. 2 - Black 2 Way -- Fuel Injector No. 3 - Black 2 Way -- Fuel Injector No. 4 - Black 2 Way -- Fuel Injector No. 5 - Black 2 Way -- Fuel Injector No. 6 - Black 2 Way -- Fuel Injector No. 7 - Black 2 Way -- Fuel Injector No. 8 - Black 2 Way -- Fuel Injector No. 9 - Black 2 Way -- Fuel Injector No. 10 - Black 2 Way -- Fuel Tank Module - Gray 4 Way -- Generator - Gray 2 Way -- Hydraulic Cooling Module - Black 3 Way -- Idle Air Control Motor - Black 4 Way -- Ignition Coil Pack-Left - Black 4 Way -- Ignition Coil Pack-Right - Black 3 Way -- Ignition Switch - Black 5 Way -- Intake Air Temperature Sensor - Black 2 Way -- Leak Detection Pump - Black 4 Way -- Manifold Absolute Pressure Sensor - Black 3 Way -- Multi-Function Switch - Gray 20 Way -- Oxygen Sensor 1/1 Left Bank Up - Black 4 Way -- Oxygen Sensor 1/2 Left Bank Down - Black 4 Way -- Oxygen Sensor 2/1 Right Bank Up - Black 4 Way -- Oxygen Sensor 2/2 Right Bank Down - Black 4 Way -- Fuses (Pdc) -- A/C Compressor Clutch Relay -- Auto Shut Down Relay -- Fuel Pump Relay -- Oxygen Sensor Heater Relay -- Run/Acc Relay -- Starter Motor Relay -- Powertrain Control Module C1 - Black/Black 32 Way -- Powertrain Control Module C2 - Black/White 32 Way -- Powertrain Control Module C3 - Black/Gray 32 Way -- Push-Button Starter Switch - Natural 6 Way -- Reverse Lock-Out Solenoid - White 2 Way -- Skip Shift Solenoid - White 2 Way -- Throttle Position Sensor - Black 3 Way -- Tire Pressure Monitor Module - Blue 6 Way -- Vtss Led - Black 2 Way -- 10.0 SCHEMATIC DIAGRAMS -- 11.0 CHARTS AND GRAPHS -- 11.1 O2 Sensor Configuration -- 11.2 Vacuum Readings -- 11.3 Cam And Crank Sensors Patterns -- 11.4 Eeld CHASSIS - ZB Chassis -- TABLE OF CONTENTS -- 1.0 INTRODUCTION -- 1.1 System Coverage -- 1.2 Six-Step Troubleshooting Procedure -- 2.0 IDENTIFICATION OF SYSTEM -- 3.0 SYSTEM DESCRIPTION AND FUNCTIONAL OPERATION -- 3.1 Teves Mark 20e System Description -- 3.2 Diagnostic Trouble Codes -- 3.3 Freeze Frame -- 3.4 Using The Drbiii -- 3.5 Drbiii Error Messages -- 4.0 DISCLAIMERS, SAFETY, WARNINGS -- 4.1 Disclaimers -- 4.2 Safety -- 4.3 Warning -- 4.4 Diagnosis -- 5.0 REQUIRED TOOLS AND EQUIPMENT -- 6.0 GLOSSARY OF TERMS -- 7.0 DIAGNOSTIC INFORMATION AND PROCEDURES -- Brakes (Cab) -- Communication -- Verification Tests -- 8.0 COMPONENT LOCATIONS -- 8.1 Controller Antilock Brake (Cab) -- 8.2 Data Link Connector -- 8.3 Hydraulic Control Unit (Hcu) -- 8.4 Power Distribution Center -- 8.5 Message Centers -- 8.6 Wheel Speed Sensors -- 8.7 Wheel Speed Sensor Connectors -- 8.8 Brake Lamp Switch -- 8.9 Abs Pump Motor -- 9.0 CONNECTOR PINOUTS -- Abs Pump Motor (Connector Side) - 2 Way -- Brake Lamp Switch - Black 6 Way -- Controller Antilock Brake - Black 24 Way -- Data Link Connector - Black 16 Way -- Fuses (Pdc) -- Wheel Speed Sensor-Left Front - Lt.Gray 2 Way -- Wheel Speed Sensor-Left Rear - Gray 2 Way -- Wheel Speed Sensor-Right Front - Lt.Gray 2 Way -- Wheel Speed Sensor-Right Rear - Gray 2 Way -- 10.0 SCHEMATIC DIAGRAMS -- 10.1 Teves Mark 20e Controller Antilock Brake ? Abs BODY - ZB BUX Body -- TABLE OF CONTENTS -- 1.0 INTRODUCTION -- 1.1 System Coverage -- 1.2 Six-Step Troubleshooting Procedure -- 2.0 IDENTIFICATION OF SYSTEM -- 3.0 SYSTEM DESCRIPTION AND FUNCTIONAL OPERATION -- 3.1 Airbag System -- 3.2 Audio System -- 3.3 Body Control Module -- 3.4 Chime Warning System -- 3.5 Communication -- 3.6 Door Ajar System -- 3.7 Exterior Lighting System -- 3.8 Relays Controlled By The Bcm -- 3.9 Heating & A/C System -- 3.10 Instrument Cluster / Gauge Cluster -- 3.11 Interior Lighting -- 3.12 Tire Pressure Monitoring System (Tpms) -- 3.13 Power Door Entry System -- 3.14 Power Windows -- 3.15 Electrically Heated Systems -- 3.16 Vehicle Theft Security System -- 3.17 Using The Drbiii -- 3.18 Drbiii Error Messages -- 3.19 Drbiii Does Not Power Up (Blank Screen) -- 3.20 Display Is Not Visible -- 4.0 DISCLAIMERS, SAFETY, WARNINGS -- 4.1 Disclaimers -- 4.2 Safety -- 4.3 Warnings -- 5.0 REQUIRED TOOLS AND EQUIPMENT -- 6.0 GLOSSARY OF TERMS -- 7.0 DIAGNOSTIC INFORMATION AND PROCEDURES -- Airbag -- Audio -- Chime -- Communication -- Door Ajar -- Electrically Heated Systems -- Exterior Lighting -- Heating & A/C -- Ignition, Power, Accessory -- Instrument Cluster -- Interior Lighting -- Power Door Locks/Rke -- Power Windows -- Tire Pressure Monitoring -- Vehicle Theft/Security -- Windshield Wiper & Washer -- Verification Tests -- 8.0 COMPONENT LOCATIONS -- 8.1 Airbag System -- 8.2 Body Control Module -- 8.3 Heating & A/C System -- 8.4 Instrument Panel -- 8.5 Power Window Motor -- 8.6 Power Door Locks -- 8.7 Tire Pressure Monitor Module (Tpm) -- 8.8 Vehicle Theft Security System (Vtss) -- 9.0 CONNECTOR PINOUTS -- Body Control Module C3 - Black/White 34 Way -- Body Control Module C4 - Black/Gray 34 Way -- C108 (Export) - Dk. Gray (Headlamp And Dash Side) -- C108 (Export) - Lt. Gray (Relay Harness Side) -- C304 (Export) - Black (Body Side) -- C304 (Export) - Black (Rear Fog Lamp Side) -- Exhaust Solenoid (Export) - Black 2 Way -- Exhaust Solenoid Relay (Export) - 5 Way -- Export Accessory Fuse -- Fog Lamp-Left Rear (Export) - 2 Way -- Fog Lamp-Right Rear (Export) - 2 Way -- Headlamp Washer Pump Motor (Export) - Black 2 Way -- Headlamp Washer Pump Relay (Export) - 5 Way -- Multi-Function Switch - Gray 20 Way -- Rear Fog Lamp Relay (Export) - 5 Way -- Side Repeater Lamp-Left (Export) - Black 2 Way -- Side Repeater Lamp-Right (Export) - Black 2 Way -- 10.0 SCHEMATIC DIAGRAMS -- 10.1 Airbag System -- 10.2 Audio System -- 10.3 Chime System -- 10.4 Communication -- 10.5 Door Ajar System -- 10.6 Electrically Heated Systems -- 10.7 Exterior Lighting -- 10.8 Heating & A/C System -- 10.9 Ignition, Power, Accessory -- 10.10 Instrument Cluster/Gauge Cluster -- 10.11 Interior Lighting -- 10.12 Power Door Locks/Rke -- 10.13 Power Window System -- 10.14 Tire Pressure Monitor Module (Tpm) -- 10.15 Vehicle Theft Security System -- 10.16 Wiper System
Dodge Viper (ZB) - Repair, Service and Maintenance Manual
inicio - index
coche - car
moto
4x4
quad - buggy
cami?n - truck
e-mail