Toyota MR2 MK2

toyota%20mr2%20mk2%20-%20workshop,%20service,%20repair%20manual%20-%20wiring.gif

TOYOTA MR2 MK2 - WORKSHOP, SERVICE, REPAIR MANUAL - WIRING

- English Workshop Manual, to vehicles Toyota MR2 MK2.

CONTENTS:

REPAIR MANUAL 1991

VOLUME 1.

- Contents 
- Introduction 
- How to use this manual 
- Identification information 
- General repair instructions 
- Precautions for vehicles with Airbag 
- Precautions for vehicles with catalytic converter 
- Precautions for vehicles with audio and anti-theft systems 
- Vehicle lift and support locations 
- Abbreviations 
- Maintenance 
- Maintenance schedule 
- Maintenance operations 
- General maintenance 
- Engine Mechanical 
- Descritption (3S-GTE) 
- Description (5S-FE) 
- Troubleshooting 
- Engine tune-up 
- Toyota-variable induction system 
- Idle and/or 2,500 RPM HC/CO checking 
- Compression check 
- Timing belt (3S-GTE) 
- Timing belt (5S-FE) 
- Cylinder head (3S-GTE) 
- Cylinder head (5S-FE) 
- Cylinder block (3S-GTE) 
- Cylinder block (5S-FE) 
- Exhaust System 
- Exhaust pipes and heat insulators 
- Turbocharger System 
- Description 
- Precautions 
- Troubleshooting 
- Turbocharger 
- Intercooler 
- Emission Control Systems 
- 3S-GTE 
- System purpose 
- Component layout and schematic drawing 
- Positive crankcase ventilation system 
- Fuel evaporative emission control system 
- Exhaust gas recirculation system 
- Three-way catalyst system 
- 5S-FE 
- System purpose 
- Component layout and schematic drawing 
- Positive crankcase ventilation system 
- Fuel evaporative emission control system 
- Exhaust gas recirculation system 
- Three-way catalyst system 
- EFI System 
- Description 
- Precautions 
- Inspection precautions 
- Troubleshooting 
- Diagnosis system 
- Troubleshooting with volt/ohmmeter 
- Fuel System 
- Fuel pump 
- Cold start injector (3S-GTE) 
- Cold start injector (5S-FE) 
- Fuel pressure regulator (3S-GTE) 
- Fuel pressure regulator (5S-FE) 
- Injectors (3S-GTE) 
- Injectors (5S-FE) 
- Fuel tank and lines 
- Air Induction System 
- Air flow meter (3S-GTE) 
- Throttle body (3S-GTE) 
- Throttle body (5S-FE) 
- Idle speed control valve (3S-GTE) 
- Idle speed control valve (5S-FE) 
- Electronic Control System 
- Location of electronic control parts 
- EFI main relay 
- Circuit opening relay 
- Cold start injector time switch 
- Solenoid resistor (3S-GTE) 
- Fuel pump relay and resistor (3S-GTE) 
- Fuel pressure VSV (5S-FE) 
- T-VIS VSV (3S-GTE) 
- Turbocharging pressure VSV (3S-GTE) 
- EGR VSV 
- Water temperature sensor 
- Intake air temperature sensor (5S-FE) 
- Vacuum sensor (5S-FE) 
- Turbocharging pressure sensor (3S-GTE) 
- EGR gas temperature sensor (3S-GTE & 5S-FE Calif. only) 
- Oxygen sensor (main) 
- Sub-oxygen sensor (5S-FE Calif. only) 
- Electronic controlled unit (ECU) 
- Fuel cut RPM 
- Cooling System 
- Description 
- Troubleshooting 
- Engine coolant check 
- Replacement of engine coolant 
- Water pump 
- Thermostat 
- Radiator 
- Electric cooling fans 
- Radiator cooling fans (w/ A/C) 
- Radiator cooling fan (w/o A/C) 
- Engine compartment cooling fan (3S-GTE) 
- Lubrication System 
- Description 
- Troubleshooting 
- Oil pressure check 
- Replacement of engine oil and oil filter 
- Oil pump 
- Oil cooler (3S-GTE)

- Oil cooler (5S-FE) 
- Oil Nozzles (3S-GTE) 
- Ignition System 
- Precautions 
- Troubleshooting 
- Ignition system circuit 
- On-vehicle inspection (3S-GTE) 
- On-vehicle inspection (5S-FE) 
- Distributor (3S-GTE) 
- Distributor (5S-FE) 
- Starting System 
- Troubleshooting 
- Starter 
- Starter relay 
- Clutch start switch (M/T only) 
- Charging System 
- Precautions 
- Troubleshooting 
- On-vehicle inspection 
- Alternator 
- Ignition main relay 
- Service Specification 
- Maintenance 
- Engine Mechanical (3S-GTE) 
- Engine mechanical (5S-FE) 
- Exhaust system 
- Turbocharger system 
- EFI system (3S-GTE) 
- EFI system (5S-FE) 
- Cooling system 
- Lubrication system 
- Ignition system 
- Starting system 
- Charging system 
- Lubricant 
- Standard Bolt Torque Specifications 
- Standard Bolt Torque Specifications

VOLUME 2.

- Contents 
- Clutch 
- Troubleshooting 
- Check and adjustment of clutch pedal 
- Bleeding of clutch system 
- Inspection of clutch start system 
- Clutch master cylinder 
- Clutch release cylinder 
- Clutch unit 
- Manual Transaxle 
- Description 
- Precautions 
- Troubleshooting 
- Removal and installation of transaxle 
- S54 Transaxle / SW21 series 
- Removal of component parts 
- Component parts 
- Input shaft assembly 
- Output shaft assembly 
- Shift and select lever assembly 
- Differential 
- Installation of component parts 
- E153 Transaxle / SW20 series 
- Removal of component parts 
- Component parts 
- Input shaft assembly 
- Output shaft assembly 
- Oil pump 
- Shift and select lever shaft 
- Differential 
- Installation of component parts 
- Shift lever and control cable 
- Automatic Transaxle (A241E) 
- Description 
- Operation 
- Troubleshooting 
- Basic Troubleshooting 
- Genaral troubleshooting 
- Preliminary check 
- Diagnosis system 
- Electronic control system 
- Mechanical system tests 
- Road test 
- Automatic shift schedule 
- On-vehicle repair 
- Removal and installation of transaxle 
- Torque converter 
- Removal of component parts 
- Component parts 
- General notes 
- Second coast brake 
- Oil pump 
- Direct clutch 
- Forward clutch 
- Front planetary gear 
- Second brake 
- Rear planetary gear 
- First and reverse brake 
- Intermediate shaft 
- Counter shaft 
- Underdrive clutch and one-way clutch no. 3 
- Underdrive brake and B4 accumulator piston 
- Valve body 
- Differential 
- Installation of component parts 
- Shift lock system 
- Suspension and Axle 
- Troubleshooting 
- Wheel alignment 
- Front wheel alignment 
- Rear wheel alignment 
- Front axle hub 
- Front suspension 
- Front shock absorber 
- Ball joints, lower arm and stabilizer bar 
- Rear axle shaft and carrier 
- Rear drive shaft (5S-FE engine) 
- Rear drive shaft (3S-GTE engine) 
- Rear suspension 
- Rear shock absorber 
- Ball joint, lower arm and stabilizer bar 
- Engine lateral control rod 
- Brake System 
- Precautions 
- Troubleshooting 
- Checks and adjustments 
- Master cylinder 
- Brake booster 
- Front brake 
- PE36T disc (for 3S-GTE) 
- PD51 disc (for 5S-FE) 
- Rear brake 
- Proportioning and by-pass valve 
- Anti-lock brake system 
- Description 
- Diagnosis system 
- Troubleshooting 
- Speed sensor diagnosis system 
- ABS actuator 
- Control relays 
- Front speed sensor 
- Rear speed sensor 
- Anti-lock brake system circuit 
- Steering 
- Precautions 
- Troubleshooting 
- On-vehicle inspection 
- Steering column 
- Manual steering gear housing 
- Power steering 
- Description 
- On-vehicle inspection 
- Power steering pump 
- Gear housing 
- Electronic control system 
- Diagnosis system 
- Inspection of electronic control components 
- SRS Airbag 
- General description 
- Description 
- Operation 
- Inspection items and replacement requirements 
- Removal and installation of component parts 
- Steering wheel pad and spiral cable 
- Front airbag Sensor 
- Center airbag sensor assembly 
- Replacement of repair wire for front airbag sensor 
- Troubleshooting 
- Disposal of steering wheel pad (with airbag) 
- Disposal of center airbag sensor assembly 
- Body Electrical System 
- General information 
- Power source 
- Ignition switch 
- Lighting system 
- Wiper and washer system 
- Combination meter 
- Defogger system 
- Power window control system 
- Power door lock control system 
- Power mirror control system 
- Cruise control system 
- Theft deterrent system 
- Audio 
- Clock 
- Body 
- General information 
- Hood 
- Front Hood 
- Engine Hood 
- Headlight 
- Front door 
- Luggage compartment door 
- Mouldings 
- Windshield moulding 
- Body outside moulding 
- Side protection moulding 
- Back window moulding 
- Windshield 
- Quarter window glass 
- Back window glass 
- T-bar roof 
- Moon roof 
- Instrument panel 
- Seat 
- Seat belts 
- Body dimensions 
- Air Conditioning System 
- General information 
- Description 
- Preparation 
- Troubleshooting 
- Refrigeration system 
- Drive belt 
- Refrigeration lines 
- Compressor 
- Receiver 
- Condenser 
- Cooling unit 
- Evaporator 
- Expansion valve 
- Thermistor 
- A/C control assembly 
- Pressure switch 
- Water temperature sensor 
- Servomotors 
- Blower motor 
- Condenser fan motor 
- Heater main relay 
- Magnetic clutch relay 
- Fan main relays 
- Vacuum hose circuit 
- Vacuum switching valve 
- A/C amplifier 
- Service Specifications 
- Clutch 
- Manual transaxle (S54) 
- Manual transaxle (E153) 
- Automatic transaxle (A241E) 
- Suspension and axle 
- Brake system 
- Steering 
- SRS Airbag 
- Body 
- Lubricant 
- Standard Bolt Torque Specifications 
- Standard Bolt Torque Specifications 
- Special Service Tools and Materials 
- Special service tools 
- Special service materials 
- Electrical Wiring Diagrams 
- Abbreviations 
- How to read this section 
- System index

WIRING DIAGRAMS 1991

- Contents 
- Introduction 
- How to use this manual 
- Troubleshooting 
- Abbreviations 
- Glossary of terms and symbols 
- Relay locations 
- Electrical wiring routing 
- Power source (current flow chart) 
- System circuits 
- Abs 
- Auto antenna 
- Back-up light 
- Charging 
- Cigarette lighter and clock 
- Combination meter 
- Cruise control 
- Door lock 
- Ect and a/t indicator light 
- Electro-hydraulic power steering 
- Engine control 
- Engine compartment cooling fan 
- Fog light (usa) 
- Heaadlight (usa) 
- Headlight and fog light (canada) 
- Horn 
- Illumination 
- Interior light 
- Light auto turn off 
- Power source 
- Power window 
- Radiator fan and air conditioner 
- Radio and player 
- Rear window defogger 
- Remote control mirror 
- Shift lock 
- Srs airbag 
- Starting and ignition 
- Stop light 
- Taillight 
- Theft deterent 
- Turn signal and hazard warning light 
- Unlock and seat belt warning 
- Wiper and washer 
- Ground points 
- Electrical wiring diagrams 
- How to read this section 
- System index

Toyota MR2 MK2 - Workshop Manual - Wiring Diagrams

inicio - index

coche - car

moto

4x4

quad - buggy

cami?n - truck

e-mail

SERVICE, REPAIR, WORKSHOP MANUAL - WIRING

Toyota MR2 MK2 - Workshop Manual - Wiring Diagrams